NTT DoCoMo and Mitsubishi Electric are planning to replace about 1.3 million batteries manufactured by Sanyo Electric because they may overheat and catch fire, the companies said Thursday.The batteries were manufactured before June of this year and are used in NTT DoCoMo\u2019s D902i handset. Some may have also been used in two other models of Mitsubishi Electric phone\u2014the D902iS and D903iS, the companies said. The batteries carry the model number "D06.""In rare cases there is a slight deformation of the electrode plate which causes it to come into contact with the insulation sheet, and hence the insulation sheet can become damaged," said Richard Sedgwick, a spokesman for Sanyo in Tokyo. "If the battery was also damaged through an outside side\u2014for example, if the user dropped the battery\u2014then the problem could occur."NTT DoCoMo said it has confirmed one case of the battery rupturing because of the problem and knows of 17 other cases where the D06 battery has ruptured or overheated. The carrier said the battery had been subject to an "extremely strong impact" in a number of the cases.Sanyo said it began examining ways of strengthening the electrode in April this year as a precautionary measure against possible problems, but at the time had not heard any reports about actual problems. Batteries with stronger plating on the electrode began rolling off the company\u2019s production line in June; hence, Thursday\u2019s advisory concerns only batteries manufactured until May.The\u00a0situation brings back memories of Sony\u2019s battery problems of earlier this year. About 9.6 million Sony-manufactured laptop computer batteries were recalled or voluntarily replaced by many laptop PC vendors after batteries in several PCs overheated and caught fire. The problem was traced back to metal particles that had gotten into the battery during manufacturing.Sony estimated the problems will cost it approximately 51 billion yen (US$444 million) this financial year.Sanyo said it has yet to work out with NTT DoCoMo and Mitsubishi Electric the part it will play in the replacement.Sanyo and Sony are two of the world\u2019s largest manufacturers of lithium ion batteries.-Martyn Williams, IDG News Service (Tokyo Bureau)Related Link:\n\nSony Battery Recalls: Who\u2019s Next?Check out our CIO News Alerts and Tech Informer pages for more updated news coverage.